Thank you. Great answer.

If I understand correctly you are talking about what is called reworking chocolate. 

Using chocolate as an ingredient to make another batch of chocolate.

In all factories chocolate batches fail from time to time (gritty, sandy or too low viscosity) and there are various methods for reworking the product.

All of them require calculations so finished product has the same composition as intended and lecithin content must be taken into consideration.

Side note:

We use conches to make chocolate and to achieve best results we add ~0.05% lecithin at the very beginning and 0.2-0.3% at the end just before final cocoa butter additions. With final content about 0.3%. This gives us the best conching profiles.

Taking above into consideration my rework recipe uses failed batch (which already contains 0.3% lecithin)  at 10% of the mixer recipe with no additional lecithin added and other ingredients adjusted. Mix gets processed in the refiners and loaded into the conche. This means that I will start with less than 0.05% of lecithin in the conche.

To sum up.

Chocolate can be reworked but only as a small part of new batch if one seeks consistency. 

Hi, 

I'm living in Israel.

In a regular process I add no more then 0.5% lecithinm and add it in the last quarter of the grinding. As I mentioned just when I have no other choices I regrined it.

The question is: Regrinding is bad for my chocolate? or in other words: once you finish to produce chocolate, you can't just grined it again and again to see the difference?

LLY - 

Where are you located?

If I purchase a commercial couverture that has lecithin in it I can incorporate ingredients that need to be ground in (coffee beans for example). I would depend a lot on the ingredients to be ground in.

There is a maximum amount of lecithin that can be added to a recipe before it starts to have the reverse effect, and you want to add the lecithin as late as possible in the process.

--
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
@DiscoverChoc

Hi,
I'm now in a process of reaching to final recipes. So, many small changes are taking place.
I'm living in a very hot and humid country (almost 40 C outside - around 27 C inside), is it possible to regrinding the chocolate with the lecithin inside and combined with more ingredients?
I found that maybe the lecithin and the humid enviroment cause the chocolate to thicken (maybe more then usual and increase the lecithin from 0.3 to 0.5 didn't help).
Am I right, the lecithin trap the humidity inside?

Thank's

updated by @lly: 04/11/25 09:27:36